This phenomenal cooling technology from Freus, shouldn’ t be confused by using a swamp cooler. Although water must be used to assist with your cooling, it is sprayed over condensing coils in lieu of pads.
The water cooled condensing unit is often a residential application of a 250 ton split system chillers already spent on commercial buildings. Think from this technology as a mini-chiller for residential use.
Evaporative water cooler units for split system air conditioners have various advantages over air-cooled versions. Water removes heat within the condenser coils far well than air. This reduces the temperature within the compressed R-22 refrigerant, which inturn reduces the work load for the scroll compressor. Not only will the compressor last a lot longer, there is only the minimum loss of cooling efficiency as soon as the outdoor temperature exceeds 100 certifications.
Typical air cooled units can lose nearly 25% of their efficiency inside the same temperature.
How much could you save with a water cooled condensing unit?
Charles Mullin, a casino worker what person lives in North Nevada is also single. So every utility bill is produced by his lone paycheck. Shoppers he switched the a / c system on his 1, 500-square-foot home towards a water cooled condensing unit.
"Before I installed the software, I had my thermostat place at 75 to 78 degrees to keep my electric debts down, " he talked about. "I tested the new system at 65 degrees - felt as being a meat locker. My bill occurred to $86. That's a few 45-percent savings and your own home was set cooler. inch
Mullin told all his friends with regards to the units and the personal savings he's seen. He figured the Freus system likely pay for itself in about a couple of years.
Richard Waite, president involving Hal Mechanical, installer involving Mr. Mullin’ s normal water cooled AC, said they're just specifically made for the actual desert climate.
“ The only extra you may need to swap out an old air conditioner for a new water-cooled you are to run a water line to it. The unit has some sort of automated system, similar to your toilet tank, keeping the pool at the correct capability. The system also flushes itself to stop calcium buildup. ”
With the almost constant capacity, the condenser size doesn't need to vary due to climate zones, like air-cooled devices. The Freus is installed in a very similar manner as an air-cooled condenser there are the unique ability towards service multiple air handlers. This provides the place saving convenience of housing two to three compressors (up to 10 total tons) within a cabinet.
Jim Kilby involving Green Valley, a internet casino management professor, replaced his 10-year-old air conditioners, one 5-ton and a 3-ton, with two water-cooled ones of roughly similar capacity. He figures his electric bills dropped by just a third.
"The hotels have already been using this technology consistently, " Kilby said. "When you think of it, water does a more satisfactory job of cooling the atmosphere than air. It just is wise. "
Whether you speak to them evaporative water refridgerators or water cooled condensing devices, this mini version in the 250 ton chiller will most likely revolutionize desert cooling.
